Grandhall Maxim Built-In manual

Grandhall Maxim Built-In
9.4 · 1
PDF manual
 · 32 pages
English
manualGrandhall Maxim Built-In
2
SPIDERS AND INSECTS CAN OCCASIONALLY
SPIN WEBS OR MAKE NESTS IN THE BURNER
TUBES. THESE
CAN OBSTRUCT GAS FLOW
WHICH COULD RESULT IN A FIRE.
THIS IS KNOWN AS ‘FLASH-BACK’ AND CAN
CAUSE SERIOUS DAMAGE TO BBQ AND CREATE
AN UNSAFE OPERATING ENVIRONMENT.
FREQUENT INSPECTION AND CLEANING OF THE
BURNER TUBES IS RECOMMENDED.
FLASH-BACK
Turn off gas at its source and turn the burner
control(s) to ‘OFF’. Wait until cooled, then clean
burner tubes and burner ports.
CLEANING THE GRILLPLATES
Allow to cool before washing in a warm soapy
solution. Use a wash cloth, a vegetable brush, or
steel wool.
CLEANING THE FLAMETAMER
Periodically wash in a warm soapy solution.
Use a wire brush to remove stubborn burnt on
cooking residue if necessary. Dry thoroughly
before re-installing in the BBQ body.
Only for Premium GT and Maxim GT.
CLEANING THE GREASE RECEPTACLE
Allow contents to cool before emptying and
washing in liquid detergent.
BUTANE OR PROPANE?
There are two different types of gas that can be used
on your gas BBQ. It is important that you use the
correct regulator for the types of gas you buy.
The following gas cylinder sizes are recommended:
Butane: > 7 kg. Propane: > 6 kg.

MAINTENANCE

DO NOT ALLOW CHILDREN TO OPERATE BBQ.
ACCESSIBLE PARTS MAY BE VERY HOT, KEEP
CHILDREN AWAY.
ANY MODIFICATION OF THIS BBQ MAY BE
DANGEROUS.
DO NOT MOVE THIS BBQ DURING USE.
TURN OFF THE GAS SUPPLY AT THE GAS
CYLINDER AFTER USE.
READ THE INSTRUCTIONS BEFORE USING
THE BBQ.
PARTS SEALED BY THE MANUFACTURER OR
THEIR AGENT MUST NOT BE MANIPULATED
BY THE USER.
THIS BBQ IS ONLY TO BE USED OUTDOORS.
BBQ SPECIFICATIONS CAN BE FOUND ON
THE DATA LABEL ATTACHED ON THE SIDE
PANEL OF THE BBQ TROLLEY.
DO NOT STORE OR USE PETROL OR OTHER
FLAMMABLE VAPOURS AND LIQUIDS NEAR
BBQ.
DO NOT STORE EMPTY OR FULL SPARE GAS
CYLINDERS UNDER OR NEAR BBQ.
KEEP THE GAS HOSE AND ANY ELECTRICAL
CORD AWAY FROM HOT SURFACES.
AVOID UNNECESSARY TWISTING OF HOSE.
VISUALLY INSPECT HOSE PRIOR TO EACH USE
FOR CUTS, CRACKS, EXCESSIVE
WEAR OR
OTHER DAMAGE.
THE HOSE MUST BE REPLACED IF
DAMAGED AND WHEN NATIONAL
CONDITIONS REQUIRE IT.
NEVER LIGHT
BBQ WITH HOOD CLOSED.
NEVER LEAN OVER COOKING SURFACE WHILE
LIGHTING BBQ.
USE BBQ TOOLS WITH WOOD HANDLES OR
GOOD QUALITY INSULATED OVEN MITTS
WHEN OPERATING BBQ.
NEVER ALTER OR MODIFY THE REGULATOR
OR GAS SUPPLY ASSEMBLY.
• Never operate this BBQ without a regulator.
Depending on which gas you decide to use, you
will need to approach your local gas dealer for a
regulator. Following supply pressures are a guide
only:
For :
Butane - 30 millibars
Propane - 30 millibars
}
I 3B/P (30)
For :
Butane - 28 millibars
Propane - 37 millibars
}
I 3+ (28 - 30/37)
For :
Butane - 50 millibars
Propane - 50 millibars
}
I 3B/P (50)
The regulator and hose assembly:
Must be suitable for liquified
petroleum gas (LPG).
Must withstand the above pressures.
Must not exceed 1.0 metre in length.
The BBQ is supplied with a loose elbow adaptor
that is suitable for direct conection of a flexible
hose.
Use appropriate Jubilee clip or twin-eared fastener
to connect hose to BBQ adaptor to secure the
hose/regulator connection.
After the assembly has been secured, turn on the
gas and check for leaks. See Checking For Gas
Leaks. Ensure this procedure is carried out in a
flame free atmosphere.
LOCATION OF YOUR BBQ
Not to be used in garages, porches, breezeways,
sheds or other enclosed areas.
Not to be used on recreational vehicles.
Do not obstruct the flow of combustion and
ventilation air around the BBQ.
CHECKING FOR GAS LEAKS
NOTE:
Never test for leaks with an open flame.
If you smell gas, turn off
at source.
Prior to first use, and at the beginning of each new
season (or, whenever gas cylinder is changed), it is
a must for you to check for gas leaks.
1. Make soap solution of one part liquid detergent
and one part water.
2. Turn burner control(s) to ‘OFF’, then turn on gas
at source.
3. Apply the soap solution to all gas connections.
Bubbles will appear in the soap solution if
connections are not properly sealed. Tighten or
repair as necessary.
4. If you have a gas leak you cannot rectify, turn off
the gas at the source, disconnect hose and
immediately call your BBQ dealer or supplier for
assistance.
GAS CONNECTIONS
Use gas regulator and hose complying with local
regulations.
GAS CYLINDER SAFETY
Never store gas cylinder indoors.
Keep gas cylinder in an upright position.
Close cylinder valve when BBQ is not in use.
Do not subject gas cylinder to excessive heat.
Exchange cylinder away from any ignition source.

WARNINGS INFORMATION SAFETY INFORMATION

GENERAL INFORMATION

Burning-off the grillplate after each use will keep it
ready fo
r instant use. Once a year, give the entire
BBQ a thorough cleaning.
INTERIOR:
Turn the burner controls to ‘OFF’ position and
disconnect gas supply.
Detach the hose/regulator assembly from BBQ.
Remove and clean the cooking plates,
flametamers and burners.
Cover gas valve orifices with aluminium foil.
Brush the inside and bottom of the BBQ body with
a stiff wire brush. Wash with a mild soap and
warm water solution. Rinse thoroughly and dry.
Remove aluminium foil from orifices and check
for obstruction.
Check spark electrode, adjusting if necessary.
Replace burners and adjust spark electrode
collector box.
Replace other components.
Reconnect to gas and light test.
Proper care and maintenance will keep BBQ in top
operating condition and prolong life.

ANNUAL CLEANING OF BBQ

SENLNOFIDK
IS GR IT ES LU PT CHFRBEIEGB
DE AT
GBIE

Manual

View the manual for the Grandhall Maxim Built-In here, for free. This manual comes under the category barbecues and has been rated by 1 people with an average of a 9.4. This manual is available in the following languages: English. Do you have a question about the Grandhall Maxim Built-In or do you need help? Ask your question here

Need help?

Do you have a question about the Grandhall and is the answer not in the manual?

  • Receive updates on solutions
  • Get answers to your question

Question and answer

Number of questions: 0

Grandhall Maxim Built-In specifications

Below you will find the product specifications and the manual specifications of the Grandhall Maxim Built-In.

General
BrandGrandhall
ModelMaxim Built-In
Productbarbecue
LanguageEnglish
FiletypeUser manual (PDF)

Frequently Asked Questions

Can't find the answer to your question in the manual? You may find the answer to your question in the FAQs about the Grandhall Maxim Built-In below.

How do I remove rust from my Grandhall barbecue?

1. Soak the rusty part in vinegar until completely soaked through. 2. Let the vinegar work on the rust for 24 hours. 3. Remove the rust with a wire brush or aluminium foil.

How do you prevent meat from sticking to the BBQ grill?

Grease the BBQ grid with oil beforehand.

How do I clean the BBQ grill?

Rub the BBQ grid with a wad of aluminium foil to clean the grid easily.

What should I do if the igniter fails to produce a spark when trying to light the burner with the lid open?

1. Ensure the lid is open before attempting to light the burner. 2. Push and turn the required burner to the 'HI' position to automatically ignite the burner. 3. If the igniter fails to produce a spark, use a match to light the burner. 4. Check for any obstructions in the gas line and remove them if present. 5. Verify the alignment of the igniter on the burner and adjust if necessary. 6. Wait for at least five minutes before attempting to re-ignite if necessary. 7. If the BBQ still fails to operate properly, consult your BBQ dealer or a gas appliance service person for further assistance.

How can I troubleshoot if the burner does not light even after following the lighting procedure with the lid open?

To troubleshoot if the burner of your Grandhall Maxim Built-In barbecue does not light after following the lighting procedure with the lid open, follow these steps: 1. Ensure the lid is open before attempting to light the burner. 2. Push and turn the required burner to the 'HI' position to automatically ignite it. If the igniter fails to produce a spark, use a match to light the burner. 3. If the burner still does not light, turn the burner controls to 'OFF' and wait for a few minutes before trying again. 4. Check the gas supply and connections for any issues. 5. If the BBQ continues to fail to operate properly, inspect and correct any misalignment of burner tubes, obstructions in the gas line, blocked orifices, or misalignment of the igniter on the burner. 6. If all checks and corrections have been made and the BBQ still does not operate properly, consult your BBQ dealer or gas appliance service person.

Is the manual of the Grandhall Maxim Built-In available in English?

Yes, the manual of the Grandhall Maxim Built-In is available in English .

Is your question not listed? Ask your question here

No results