Bowflex Treadmill 25 manual

Bowflex Treadmill 25
7.8 · 1
PDF manual
 · 243 pages
English
manualBowflex Treadmill 25
1

Service Manual

Table of Contents

Section Code Section Page Number
Nautilus, Inc., www.NautilusInc.com, 5415 Centerpoint Parkway, Groveport, OH 43125 U.S.A. - Customer Service: North America (800) 605-3369, csnls@nautilus.com | outside U.S. www.nautilusinternational.com | Printed in
China | © 2021 Nautilus, Inc. | Bowex and the B logo are trademarks owned or licensed by Nautilus, Inc., registered or otherwise protected by common law in the United States and other nations. | ORIGINAL DOCUMENT -
ENGLISH VERSION ONLY
8028285.020123.D
8028284.020123.D

Bowex

Treadmill 10 / Treadmill 25

Service Manual

1 Important Safety Instructions 2
1 Safety Warning Labels and Serial Number 3
1 Specications 4
1 Grounding Instructions 5
1 Emergency Stop Procedure 6
1 Moving and Storing the Machine 7
1 Unfolding the Machine 9
1 Leveling the Machine 10
1 Treadmill Belt (break in period) 10
1 Connectivity 11
1 Maintenance 13
1 Cleaning 13
1 Adjusting the Belt Tension 14
1 Aligning the Walking Belt 14
1 Lubricating the Walking Belt 15
1 Maintenance Parts 16
1 Troubleshooting 18
1 Electrical Wiring Diagram 28
1 Demonstration Mode 31
1 Replacement Procedure Skill Level 32
Mechanical / Modication Procedures
2 Adjust the Deck Release Assembly 33
3 Adjust the Walking Belt 38
Part Replacement
4 Replace the Bottom Motor Cover 40
5 Replace the Circuit Breaker 52
6 Replace the Console Assembly 58
7 Replace the Console Base 64
8 Replace the Deck Release Assembly 76
9 Replace the Deck Suspension 83
10 Replace the Deck Wheel 89
11 Replace the Drive Belt 94
12 Replace the Front Roller 106
13 Replace the Incline Motor Assembly 118
14 Replace the Lower I/O Cable 127
15 Replace the Middle I/O Cable 135
16 Replace the Lift Shock 140
17 Replace the Motor 145
18 Replace the Motor Control Board (MCB) 160
19 Replace the Motor Cover 168
20 Replace the Outside Deck Shroud 170
21 Replace the Power Inlet 175
22 Replace the Rear Roller 181
23 Replace the Right-Inside Deck Shroud 189
24 Replace the Rocker Switch 193
25 Replace the Side Rail 199
26 Replace the Speed Sensor Assembly 204
27 Replace the Transport Wheel 216
28 Replace the Walking Belt 220
29 Service or Replace the Walking Deck 235

View the manual for the Bowflex Treadmill 25 here, for free. This manual comes under the category treadmill and has been rated by 1 people with an average of a 7.8. This manual is available in the following languages: English. Do you have a question about the Bowflex Treadmill 25 or do you need help? Ask your question here

Need help?

Do you have a question about the Bowflex and is the answer not in the manual?

  • Receive updates on solutions
  • Get answers to your question

Question and answer

Number of questions: 0

General
BrandBowflex
ModelTreadmill 25
Producttreadmill
LanguageEnglish
FiletypeUser manual (PDF), Instructions / Assembly (PDF)

Can't find the answer to your question in the manual? You may find the answer to your question in the FAQs about the Bowflex Treadmill 25 below.

How much should I exercise as an adult per week?

As an adult, it is recommended to do moderately intensive exercise for at least 2.5 hours per week. Preferably spread over several days.

What is an adult's maximum heart rate?

As a rule of thumb for your maximum heart rate, you can use 220 minus your age.

How can I adjust the walking belt on the Bowflex Treadmill 25 treadmill?

To adjust the walking belt on the Bowflex Treadmill 25 treadmill, follow these steps: 1. Start by running the machine at a speed of 1 mph to determine which way the walking belt needs to be adjusted. Do not touch the walking belt while it is in motion and keep bystanders, children, and pets away from the machine. 2. Locate the right and left plugs that cover the openings to the walk-in belt adjustment bolts. Remove these plugs. 3. Using a 6mm hex wrench, rotate the adjustment bolt on the side where the belt should move away from. Turn the bolt a quarter turn clockwise. 4. Allow the walking belt to adjust to the new tension. 5. Repeat steps 3 and 4 until the walking belt is centered. 6. After adjusting the walking belt, perform a final inspection of the machine. Ensure that all hardware is tight and components are properly assembled. Remember not to use the treadmill until it has been fully assembled and inspected for correct performance, as stated in the owner's manual. Please note that the information provided is based on the Bowflex Treadmill 25 treadmill manual.

What are the important safety instructions I should follow before servicing or using the Bowflex Treadmill 25 treadmill?

Before servicing or using the Bowflex Treadmill 25 treadmill, it is important to follow these safety instructions: 1. Always attach the Safety Key Clip to your clothing during your workout. This key prevents serious injury and should only be removed in an emergency. 2. Keep children and pets away from the treadmill to avoid any accidents or injuries. 3. Read and follow all warnings and safety information provided in the owner's manual. 4. Consult a physician before using the treadmill, especially if you have any underlying health conditions. 5. Cease exercising if you feel faint or dizzy to prevent any potential harm. 6. Keep your body, clothing, and fitness accessories clear of all moving parts to avoid entanglement or injury. 7. Inspect the equipment before each use and do not use if it appears damaged or inoperable. 8. Remove the Safety Key when the treadmill is not in use and store it out of reach of children. By following these important safety instructions, you can ensure a safe and enjoyable experience while using the Bowflex Treadmill 25 treadmill.

Where can I find the service procedures for the Bowflex Treadmill 25 treadmill, including important safety instructions, adjustments, and general troubleshooting information?

You can find the service procedures for the Bowflex Treadmill 25 treadmill, including important safety instructions, adjustments, and general troubleshooting information, in the manual. Here are the steps: 1. Start by flipping the power switch to the OFF position. 2. Before servicing or using the equipment, it is crucial to read and understand all the important safety instructions provided in the manual. These instructions are designed to prevent potential hazards and ensure your safety. 3. To reduce the risk of electrical shock or unsupervised usage, always unplug the power cord from the wall outlet and wait for 5 minutes before cleaning, maintaining, or repairing the machine. Place the power cord in a secure location. 4. Make sure to keep bystanders, children, and pets away from the treadmill during servicing or maintenance. 5. When performing repairs or adjustments, ensure that the work area is appropriate, away from foot traffic, and not exposed to bystanders. 6. Disconnect all power and allow the machine to sit for 5 minutes before starting any service procedures. 7. For heavy or awkward components, it is recommended to enlist the help of a second person to avoid injury. 8. When replacing parts, always use genuine Nautilus replacement parts and hardware to ensure proper functionality and avoid any risks to users. Using non-genuine parts may also void the warranty. 9. Check all warning stickers and instructional placards on the treadmill. If any become loose, unreadable, or dislodged, replace them promptly. 10. Do not attempt to modify the design or functionality of the machine during servicing, as it can compromise user safety and void the warranty. 11. Before using the treadmill again, ensure that all shrouds, instructions, warning labels, and functionality have been verified and tested for correct performance. Please note that these steps are based on the Bowflex Treadmill 25 treadmill manual.

What are some general troubleshooting tips for the Bowflex Treadmill 25 treadmill?

Here are some general troubleshooting tips for the Bowflex Treadmill 25 treadmill: 1. If the console does not light up, follow the "Unit will not power on" troubleshooting procedure. Make sure to reinsert the safety key and check if the issue is resolved. 2. If the units of measure are incorrect, refer to the owner's manual instructions to correct the setting before proceeding with troubleshooting. 3. If the safety key is damaged, replace it to ensure proper functionality. 4. If the fan does not turn on or off, turn off the machine for 5 minutes and retry. If the issue persists, disconnect the machine from power for 1 minute and follow the service mode procedure to reset the console. 5. If the speed is incorrect, ensure that the correct units of measure are set. Switch the units by going to the profile tab and updating the settings. 6. If the console continuously cycles through program screens, it may be in demonstration mode. Tap the upper-right corner of the console display 10 times and select the "De-activate Demo Mode" option from the advanced user actions menu. If these troubleshooting tips do not resolve the issue, contact customer care or your local distributor for further assistance.

What is the part replacement procedure for the Bowflex Treadmill 25 treadmill, and where can I find more information about it?

To replace a part on the Bowflex Treadmill 25 treadmill, follow these steps: 1. Start by identifying the specific part that needs to be replaced. Refer to the owner's manual or the parts diagram to ensure you have the correct replacement part. 2. Disconnect the power cord from the wall outlet and wait for 5 minutes before proceeding with the replacement procedure. 3. Carefully remove any components or parts that are obstructing access to the part that needs to be replaced. Keep track of the order in which the parts are removed for easier reassembly. 4. Remove the faulty or damaged part by following the instructions provided in the manual. Use the appropriate tools, such as a screwdriver or wrench, to safely remove any screws or fasteners. 5. Install the new part by aligning it correctly and securely attaching it using the provided hardware. Follow the reverse order of the removal steps to reassemble the treadmill. 6. After replacing the part, perform a final inspection of the machine to ensure that all hardware is tight and components are properly assembled. For more detailed information about the part replacement procedure, refer to the owner's manual of the Bowflex Treadmill 25 treadmill.

Is the manual of the Bowflex Treadmill 25 available in English?

Yes, the manual of the Bowflex Treadmill 25 is available in English .

Is your question not listed? Ask your question here

No results